L0 53810-206-12-1
-KEY-
EXPECTED TEMPERATURES
INTERVALS
LUBRICANTS
CAPACITY
Above +32F
+ 40F to -10 F
0F to -65F
HDO-OIL, Engine, Heavy Duty
Rud-O-Matic Tagline
8 qts. ea. bbl.
HDO 30
HDO 10
OES
OES-OIL, Engine, Sub-zero
GO-LUBRICANT, Gear, Universal
GO 90
GO 80
GOS
Propel Shaft Bevel Gear Case
12 qts
FOLD
FOLD
GOS-LUBRICANT, Gear, Universal, Sub-
zero
Intervals given are
in hours of normal
HB-BRAKE FLUID, Automotive
operation.
Hydraulic Oil Tank
10 qts
Swing Brake Master Cylinder
1/2 qt
HB
HB
HBA
Dipper Trip Master Cylinder
1/2 qt
HBA-BRAKE FLUID, Automotive
CW-11-B LUBRICATING OIL., Exposed
ALL TEMPERATURES
Gear
GAA-GREASE, Automotive and Artillery
NOTES:
6. LUBRICANTS. The following is a list of lubricants with the Military
1.
FOR OPERATION OF EQUIPMENT IN PROTRACTED COLD
Symbols and applicable Specification numbers.
TEMPERATURES BELOW - 10 F. Remove lubricants prescribed in the key
for temperatures above - 10 F. Relubricate with lubricants specified in the
GO MIL-L-2105
GOS MIL-L-10324
GAA MIL-G-10924
key for temperatures below - 10 F. HB FED
HDO MIL-L-45199
OFS MIL-L-10295
CW11-B VV-L-751
VV-B-680
HBA MIL-H-13910
2. OIL CAN POINTS. Every 10 service hours lubricate all linkage, pins and
devises with HDO.
Copy of this Lubrication Order will 'remain with the equipment at all times;
instructions contained herein are mandatory.
3. CABLES. Keep cables clean and lubricated with HDO. CAUTION. Do
not lubricate cables coming in contact with excavated materials.
BY ORDER OF THE SECRETARY OF THE ARMY:
4. TRAVELING. When traveling, lubricate the following points every 2
W. C. WESTMORELAND
service hours; lower vertical propel shaft bushing, lower track roller shafts,
General, United States Army
upper track support roller, outer and inner drive shaft bearings, propel chain,
Chief of Staff.
drive sprocket hub, horizontal propel shaft inboard and out-board bearings
OFFICIAL:
and idler sprocket bearing.
5. EXPOSED GEARS AND PINIONS. Keep all exposed gears and pinions
coated with CW-11.
KENNETH G. WICKHAM,
Major General, United States Army,
The Adjutant General.
LO 5-3810-206-12-1 DISTRIBUTION: To be distributed in accordance with DA Form 12-25, Sec II l(qty rqr Block #349), Operator requirements for Crone-Shovels,
Crawlers, 40 Ton.
GPO 822-260
