NOTES - CONTINUED:
6. ENGINE OIL FILTER. Filter is to be replaced each
12. CRAWLER GEARCASE HOUSING.
time an engine oil change is directed by AOAP
laboratory.
After installing new filter element, fill
Check level each 50 hours. Change gear lubricant only
crankcase, operate engine 5 minutes, check housing for
when required by maintenance repair action,
leaks, check crankcase oil level and bring to full mark.
When AOAP laboratory support is not available, Install
refill, operate for five minutes, check for leaks and bring
new filter element each 100 hours.
oil level to fill and level plug opening.
7. TRANSMISSION. Check level each 50 hours.
13. LUBRICANTS. The following is a list of lubricants
Change gear lubricant only when required by
with military symbols and applicable specification
numbers.
other foreign material. After refill, operate for five
minutes, check for leaks and bring oil level to fill and
OE/HDO
MIL-L-2104
level plug opening.
GO
MIL-L-2105
8. HYDRAULIC RESERVOIR AND HYDRAULIC OIL
GAA
MIL-G-10924
FILTER. Each 1000 hours, drain hydraulic system,
OEA
MIL-L-46167
remove filter element, clean filter housing and fill cap,
BFS
MIL-B-46176
install new filter element. Fill hydraulic reservoir,
(SD), Type II
P-D-680
operate hydraulic system for 5 minutes, check for leaks,
BR
MIL-G-18709
check level and bring to "FULL" mark.
CW
FED-VV-L-751
OHT
MIL-H-6083
9. MORIN TRIP TOGMASTER. Each 5 hours soak
thrust washers and between cams with OE/HDO. Each
Copy of this Lubrication Order will remain with the-
100 hours remove screw plug and fill drum oil-tube with
equipment at all times, instructions contained herein are
OE/HDO.
mandatory.
10. AIR CLEANER. Each 10 hours refill oil reservoir to
By order of the Secretary of the Army:
level mark. Each 50 hours disassemble entire unit,
clean, re-oil and assemble.
JOHN A. WICKHAM, JR.
General, United States Army
11. GEARCASE. Check level each 50 hours. Change
Chief of Staff
gear lubricant only when required by maintenance repair
OFFICIAL:
After refill, operate for five minutes, check for leaks and
bring oil to "FULL" mark.
ROBERT M. JOYCE
Major General, United States Army
The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-
25B, Operator and Organizational maintenance
requirements for Crane-Shovel, Crawler Mounted.
*U.S. GOVERNMENT PRINTING OFFICE: 1984-420-903/217
TA 220421
LO 5-3810-287-12
CARD 9 OF 9