LO 5-3810-294-12
NOTES - CONTINUED:
5. ENGINE OIL FILTER (CARRIER AND CRANE).
13. GEAR AND CHAIN CASE. Each 50 hours check
Each 100 hours, remove filter element, clean housing
level. Change gear lubricant only when required by
and install new filter element. After installing new filter
maintenance repair a action, contamination by water, or
element, fill crankcase, operate engine for 5 minutes,
other foreign material. After refill, operate for five
check housing for leaks, check crankcase oil level and
minutes, check for leaks and bring oil level to level plug
bring to "FULL" mark.
opening.
6. AIR CLEANER (CARRIER AND CRANE). Each 10
14. CABLES. Each 50 hours clean and coat all cables
hours, refill reservoir to level mark. Each 50 hours
with OE/HDO, except those coming in constant contact
disassemble entire unit, clean, re-oil and assemble.
with dirt or excavated material.
7. TRANSMISSION (CRANE ENGINE). Each 50 hours
15. TAGLINE. Keep tagline housing 112 full of GO.
check level. Change gear lubricant only when required
Do not overfill.
by maintenance repair action, contamination by water, or
other foreign material. After refill, operate for five
16. LUBRICANTS. The following is a list of lubricants
minutes, check for leaks and bring oil level to fill and
with military symbols and applicable specification
level plug opening.
numbers.
8. FRONT AND REAR WHEEL BEARINGS. Each
OE/HDO
MIL-L-2104
1000 hours, remove wheels, clean and inspect all parts,
GO
MIL-L-2105
replace damaged or worn parts, repack bearings and
GAA
MIL-G-10924
assemble.
OEA
MIL-L-46167
BFS
MIL-B-46176
9. STEERING GEAR HOUSING. Serviced by direct
CW
W-L-751
support maintenance at time of overhaul. Repack with
(SD), Type II
P-D-680
GAA.
Copy of this Lubrication Order will remain with the
10. MAIN TRANSMISSION/HI-LO RANGE DROP
equipment at all times, instructions contained herein are
GEARCASE. Each 250 hours check level. Change
mandatory.
gear lubricant only when required by maintenance
repair action, contamination by water, or other foreign
By order of the Secretary of the Army:
material. After refill, operate for five minutes, check for
leaks and bring oil level to fill and level plug opening.
JOHN A. WICKHAM, JR.
General, United States Army
11. TRANSFER CASE. Each 250 hours check level.
Chief of Staff
Change gear lubricant only when required by
OFFICIAL:
maintenance repair action, contamination by water, or
other foreign material. After refill, operate for five
ROBERT M. JOYCE
minutes, check for leaks and bring oil level 1 inch from
Major General, United States Army
top of level opening.
The Adjutant General
12. FRONT AXLE DIFFERENTIAUFRONT AND REAR
DISTRIBUTION:
DUAL AXLE DIFFERENTIAL. Each 50 hours check
level. Change gear lubricant only when required by
To be distributed in accordance with. DA Form 12-25B,
maintenance repair action, contamination by
Operator and Organizational Maintenance requirements
water, or other foreign material. After refill, operate for
for Truck Mounted Cranes.
TA221878
five minutes, check for leaks and bring oil level to fill and
level , plug opening.
*U.S. GOVERNMENT PRINTING OFFICE:
1984-420-903/266
CARD 12 OF 12
