any other external auxiliary lifting means. Ratings are
h. Crane-Lifting Capacities. Crane lifting capacities
based on crane standing on a firm and level supporting
are listed in table 1. Eighty-five percent of tipping rated
surface. Rated loads are in pounds over either side or
loads shown are gross hook loads measured from the
rear.
center of rotation and include the weight of the bucket and
Table 1. Crane Lifting Capacitor
Maximum capacity of crane without outriggers
Boom length
Radius
30 ft
40 ft
10
24,000 lb
------
(Use outriggers when boom length exceeds
12
------
17,700 lb
40 feet)
15
14,800 lb
13,000 lb
20
9,700 lb
8,000 lb
25
7,100 lb
6,800 lb
30
5,500 lb
4,500 lb
35
------
3,700 lb
40
------
3,200 lb
Maximum capacity of crane with outriggers (Use outriggers when boom length exceeds 40 feet)
Radius
30 ft
40 ft
50 ft
60 ft
70 ft
80 ft
90 ft
10
40,000 lb
12
------
31,000 lb
15
27,700 lb
26,300 lb
25,000 lb
24,000 lb
20
20,000 lb
19,000 lb
18,000 lb
17,000 lb
16,000 lb
25
15,500 lb
14,700 lb
13,900 lb
13,000 lb
12,200 lb
11,500 lb
10,700 lb
30
12,000 lb
11,600 lb
11,000 lb
10,200 lb
9,500 lb
9,000 lb
8,500 lb
35
------
9,100 lb
8,700 lb
8,200 lb
7,700 lb
7,300 lb
6,800 lb
40
------
7,400 lb
7,000 lb
6,700 lb
6,300 lb
5,900 lb
5,500 lb
45
------
------
5,800 lb
5,500 lb
5,100 lb
4,800 lb
4,500 lb
50
------
------
4,700 lb
4,500 lb
4,200 lb
4,000 lb
3,800 lb
Reduce main book capacity 800 pounds when jib is added. Use jib only on 50, 60, or 70 foot booms. Jib rating-
3800 pounds up to 50 foot radius.
1
Turn signal switch
23 Receptacle assembly
46
Bus bar
2
Turn signal flasher
24 Dimmer switch
47
Wire assembly
3
Warning light flasher
25 Turn light indicator (right)
48
Connector
4
'Y' Type connector
26 Turn light indicator (left)
49
Cable, generator
5
Selector switch
27 Panel light (high beams)
50
Starter button
6
Vehicular light switch
28 Buzzer
51
Ignition switch
7
Stop switch
29 Warning switch (Hi-temp)
52
Circuit breaker
8
Blackout clearance light
30 Pressure switch (Low-oil)
53
Battery-generator indicator
9
Turn light (left front)
31 Pressure transmitter
54
Horn
10
Service headlamp
32 Transmitter (water-temp)
55
Trouble lamp
11
Blackout marker and
33 Fuel sending unit
56
Pistol grip and red holder
service park light
34 Switch (low air)
57
Pistol grip and red
12
Blackout headlamp
35 Indicator light (Hi-temp)
58
Horn button
13
Clearance lamp
36 Indicator light (Low-oil)
59
Wire assembly
14
Wire assembly
37 Pressure indicator
60
Toggle switch
15
Turn light (right front)
38 Water temp indicator
61
Cab heater
16
Wiring harness, front
39 Fuel indicator
62
Wire Humbly
17
Wiring harness, rear
40 Wire assembly
63
Wire assembly
18
Wiring harness, outrigger
41 Cable
64
Outlet
19
Turn light (right rear)
42 Slave receptacle
65
Wire harness
20
Blackout tail light
43 Battery Cable (jumper)
66
Rheostat
21
Turn light (left rear)
44 Battery Cable (ground)
67
Dash light
22
Wire harness, transmission
45 Battery Cable (positive)
68
Dome light
Figure 3. Crane-shovel and carrier wiring diagram.
AGO 6819A
10
