TM 5-3810-294-34
CHAPTER 15
REPAIR OF POWER TRANSFER COMPONENTS
Section I. REPAIR OF PROPELLER SHAFTS
b. Because of their similarity, the repair of the
15-1. Description
shafts is discussed collectively below. Adequate
a. There are four propeller shafts used On the
definition is presented in the accompanying
carrier: the interaxle propeller shaft, located between the
illustration.
rear axles; the intermediate propeller shaft, located
15-2. Removal
between the transfer case and the forward-rear axle; the
Refer to TM 5-3810-294-20 and remove propeller
front axle propeller shaft, located between the front axle
shaft(s).
and the lower end yoke of the transfer case; and the
15-3. Disassembly
front propeller shaft, located between the transmission
Refer to figure 15-1 and disassemble propeller
and the transfer case. The shafts are similar in
shaft(s) to the extent necessary for repair.
construction except for length and termination (flange or
lock strap mounting).
KEY to fig. 15-1.
1. Capscrew (8)
15.
Lockwasher (8)
2. Lock strap (4,
16.
Nut (4)
3. Bearing (4)
17.
Bracket
4. Spider assembly
18.
Capscrew (4)
5. Yoke stub
19.
Bracket
6. Dust cap
20.
Clamp
7. Washer
21.
Support
8. Non-metallic washer
22.
Adapter
9. Lubrication fitting
23.
Bolt (16)
10. Yoke sleeve
24.
Companion flange (2)
11. Lubrication fitting
25.
Front axle propeller shaft
12. Intermediate propeller shaft
26.
Front propeller shaft
13. Speedometer cable
27.
Interaxle propeller shaft
14. Capscrew (41
15-1
