TM5-3810-305-10Air Cleaner - With engine running, check aircleaner restriction indicator located on outside ofhood support assembly (yellow is normal; redrequires service). Reset indicator each time hoodis opened by pushing the button on the bottom ofthe indicator. If it does not reset, notify mainte-nance.Tires - Check for proper pressure before travel-ing. Tires should only be checked when cold(refer to Recommended Tire Pressure Chart,page 1-20). Check for severe cuts and foreignobjects imbedded in tread.Cable and Blocks - Inspect hoist cable, hoistblock, hook latch and boom attachment forreadiness.Boom Head - Inspect cable retention pins andhair pin totters at boom head for correct installa-tion.CAUTIONKeep tension on cable to preventdamage from slack.Cable - Reeve hoist cable as required.Anti-Two Block System - Inspect anti-twoblock switch found on boom head for damage.Check for free movement of the counterweightattached to switch. Be sure counterweight issecured around correct line of hoisting cable inproper manner. Inspect all electrical connectionsand wires as well as the entire length of cable at-tached to the cable reel and its connections forevidence of excessive wear, damage or improperinstallation. Check cable reel for proper tensionand to insure that reel is free to rotate. Verifyvisual and audible warning devices operation bylifting counterweight.CAUTIONIf disconnects malfunction andhook block is drawn into theboom point, vehicle may bedamaged. Care should be takenwhen performing disconnect test.NOTEA warning light will appear onanti-two block panel and anaudible signal will be heard ifhorn switch is in ON position,The LRT 110 Crane is equipped with disconnectson control linkage. A check of this systemshould be made prior to lifting. Hoist hook blockso that actual contact between block and anti-twoblock counterweight is made. If all functions areoperating properly, winch hoisting will cease andboom will not extend or lower. Should any ofthese functions continue, disconnects are notworking and a complete system check must bemade. Boom retract, boom raise and winchdown functions remain active and will be unaf-fected by anti-two block system.Brake Fluid - Check reservoirs on front of dash.Fill to FULL line on reservoirs.Safety Equipment - Check safety equipment,including tall lights, parking brake, hazard warn-ing devices and fire extinguisher.Operator ObservationsAs the operator, it is your responsibility toobserve and report any unusual sounds, odors orother signs of abnormal performance that couldindicate trouble ahead. On a routine basis,during the days operations the following itemsshould be checked.4-11
Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business
