TM5-3810-305-10
1. Visual inspection - Check complete vehicle
for any unusual condition.
2. Check for any leaks or damage to the hydrau-
lic system.
3. Check engine compartment for:
l Tension and wear of belt.
l Oil level.
l Air cleaner restriction indicator.
l Air intake piping condition.
l Muffler and exhaust pipe condition.
4. Check dash gauges for proper operation.
5. Check hydraulic reservoir dipstick level.
6. Check crane boom for:
l Wear or damage to hook block.
l Wear on cable retention pin at boom head.
l Proper function of anti-two block system.
l Proper cable spooling on winch.
l Wear of cylinder pin connections.
7. Check tires, axles and drive lines for wear or
damage.
8. Check cab for:
l
l
l
l
l
l
Properly functioning instruments.
Properly operating controls.
Clean windows.
Properly functioning safety equipment<
Properly working lights.
Cleanliness - free of mud and debris.
Time Intervals - Unusual Conditions
The LRT 110 Crane will require extra service
and care when operated under unusual condi-
tions, High or low temperatures, long periods of
hard use and continued use in sand, water, mud
or snow will break down lubricants. Add or
change lubricant more often under these condi-
tions. However, during long periods when the
LRT 110 Crane is not in use, the service intervals
can be lengthened.
CabIe lnspection
All cable in active service should be inspected
DAILY along with spooling, sheaves, wedge
sockets and any other cable fittings for damage.
A thorough cable inspection should be made
WEEKLY by a competent inspector.
Refer to Section V, Wire Rope Instructions, page
4-28, for guidelines covering inspection, mainte-
nance, repair and replacement of cable.
Incorrect cable type or size will
not function properly and may be
dangerous when used. Failure to
follow this procedure could cause
DEATH or serious injury.
Before installing a new or replacement cable,
make certain cable is of the correct type and size.
Cable Specifications
The LRT 110 Crane is equipped with 180 ft
(54.86 m) of 1/2 in. diameter 6x19 IWRC IPS
cable.
4-12
